Homemade smoke generator of girlfriend
Hot smoking is soon such a variety of barbecue, baking with simultaneous smoke treatment. It is suitable for a picnic, family holiday, but cooked foods need to eat immediately. On the contrary, cold smoking is a great way to keep the products for a long time without refrigerator, vacuum, drying sublimation. What is needed for the harvesting of Harch to a hike instead of shop smokes. Besides also cheaper!
Of course, it is good for those who live in a private house. You will not build a smokehouse on the balcony. Or build?! Smart people came up with such a thing, called the "smoke generator". Wrapped with sawdust and gives it quite cold smoke - such that it is possible to smoke directly in the cardboard box of suitable size! You can easily find a bunch of structures, but I especially liked one, for which absolutely no machine or welding works. I tell.
I went to the market, I bought in a stall with Plumbing half a tee, the same fitting on the 8-mm tube, a couple of Signs (one is more authentic, the other is very short) and a pair of nickel-washers of the same diameter. By the way, for our purposes, you can take that piping and cheaper, there will be no pressures here. From the antenna of the old Chinese receiver, the thin-walled tube of a suitable diameter was broken down (should be tightly incurred inside the fitting) and picked up a piece of the rubber tube of the eight.
We still need a source of compressed air of a small pressure and with a very weak consumption. Usually use aquarium compressor, but I did not have, and at the auction there was a laptop cooler three times cheaper, so I bought it. It put the cardboard funnel with a nozzle under the same rubber tube to the squabble. To power the cooler took the old charger from the mobile phone for 5 volts.
For the furnace you need some kind of tin with a lid. Something is well suitable for design similar to a can with paint. Or what bidonchik. I have a snaps of Nishchebrodskaya, therefore a bank was attached from under canned pineapples, a bank went on the lid of the same diameter, but a lesser height from bulls in Tomat.
Article on the topic: Sliding doors in the bathroom and toilet: Tips for choosing
How everything is going to be seen in the photos. It is not even necessary to tighten the threaded connections, it is enough to spin from hand. Seal also makes no sense. Next to the bottom of the Big Banks need to cut through the slot for the air of the air of a centimeter of a centimeter and a width of a couple of millimeters. Just poke there with a knife parallel to the bottom. Through the same gap will be saturated with sawdust.
Unfortunately, the ignition process failed! A match there is difficult there, you need a lighter, better if Turbo. We turn on the duyk, bring a burning lighter to thinking and observe how the flame is drawn into the banks (the design of the tubes works as an injector, sucking air from the can). Hold the burning lighter while inside the saws do not stop, and the smoke will not go out of the open tube. We carefully blow in the gap, inflating the raincing rings, and enter the open tube inside the drawer with the products suspended in it.
By the way, the box should not be straight hermetically, there must be small gaps to exit surplus smoke. The first time I dragged the outdoor drawer with a stretch film to watch the process, at the same time blocked all the cracks, and when the pipe was thrown into a specially done hole, smoke went from all the cracks of the smoke generator itself. I had to shift the box!
Such a width banks grab about two hours of burning, depends on the air flow from the compressor. I feel so weak that the blow is not felt with the palm, however, it turned out enough. Then you can remove the lid, shine sawdust, close, fan and continue the process. Keep in mind that from the pipe in the box will drip down, so do not place the products near.
During the work of the bank with sawdust heats up, feelings - degrees to 80. That is, it's hot, of course, but a few seconds a hand tolerates. I think that with this mode, it does not quickly come back.
Article on the topic: Wenge color doors in the interior: Combination with wallpaper and floor
I tried to put a piece of a dropper with a regulator instead of a rubber tube, so that it is worth it to dispense the consumption of smoke, but this is a balobiness, you should not bother. Consumption is adjustable, but sawdust can appear.
Salo, that in the last photo, smoked for five litters of sawdust: two last night, one in the morning before leaving for work, and two more tonight. It turned out quite yellow and well smoked! However, due to the fact that smoke is served too high, the color is completely pale. It will be necessary to take into account this next time!
During operation, smoke is almost no observed, so the neighbors do not heat up where it comes the smell! And be sure to follow the rules of fire safety! From pondered sometimes the last-minute sparks fly out, so I had to put the generator inside the fire-fighting night pot! What can be shrinking even besides meat-fish-sausages? Yes, even that. Cheese, pepper on Adzhik, paprika or chipotle, plum, even salt! Smeat!